Product ID:ALUMINUM HEAT RESISTING PAINT 1200F #X-5767
MSDS Date:01/10/1996
FSC:8010
NIIN:00-857-1938
MSDS Number: CCMJH

SENTRY PAINT AND CHEMICAL COMPANY

237 MILL STREET
DARBY, PA 19023
US

Emergency Phone: 800-424-9300

Info Phone: 215-522-1900

Preparer: JUHN F. BIELSKI

Cage: 34346

SENTRY PAINT AND CHEMICAL CO

DARBY, PA 19023 US

Cage: 34346

VM&P NAPHTHA, SOLVENT TYPE

CAS: 64742-89-8

Fraction By Weight: 10-15%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

RULE 66 MINERAL SPIRITS, SOLVENT TYPE

CAS: 64742-88-7

Fraction By Weight: 40-45%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION, REDNESS, TEARING,
BLURRED VISION. SKIN: DRYNESS, IRRITATION, DERMATITIS. INHALATION:
NASAL/RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, NAUSEA,
HEADACHE. INGESTION: NAUSEA, VOMITING, DIARRHEA. ASPIRATION INTO
LUNGS CAN CAUSE CHEMICAL PNEUMONITIS.

First Aid:INHALATION: MOVE TO FRESH AIR. IF NOT BREATHING GIVE
ARTIFICIAL RESP. KEEP WARM/QUIET. GET IMMED MED AID. EYE: FLUSH
W/LARGE AMOUNTS WATER LIFTING LIDS OCCASIONALLY FOR >15 MIN. GET
MED AID. SKIN: THO ROUGHLY WASH W/SOAP & WATER. REMOVE CONTAM
CLOTHES/WASH BEFORE REUSE. INGESTION: DON'T INDUCE VOMITING. KEEP
WARM/QUIET. GET MED AID. ASPIRATION INTO LUNGS DUE TO VOMITING MAY
CAUSE CHEM PNEUMONITIS.

Flash Point Method:CC
Flash Point:40.0F,4.4C
Autoignition Temp:Autoignition Temp Text:480F
Lower Limits:0.9
Upper Limits:7.0
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL FOR SMALL FIRES. FOAM
FOR LARGE FIRES.
Fire Fighting Procedures:COOL CLOSED CONTAINERS W/WATER SPRAY NEVER
WELD/CUT ON/NEAR DRUM (EVEN EMPTY). PRODUCT/RESIDUE CAN IGNITE
EXPLOSIVELY.
Unusual Fire/Explosion Hazard:CLOSED CONTAINER MAY BUILD EXPLOSIVE
PRESSURE FROM HEAT.VAPORS >AIR.MAY TRAVEL ALONG GROUND/MOVE BY
VENTILATION/IGNITE AT LOCATION DISTANT FROM HANDLING POINT.

Spill Release Procedures:EVACUATE.REMOVE IGNIT SOURCES.DIKE/CONTAIN
W/INERT MATL (SAND/EARTH). TRANSFER LIQ TO COVERED METAL CNTNRS FOR
RECOVERY/DISPOSAL.REMOVE W/INERT ABSORBENT.USE NONSPARKING
TOOLS.DON'T CONTAM SEWERS/STRE AM/GROUND WATER W/SPILLED MATL OR
ABSORBENT.

Respiratory Protection:USE SCBA WHERE CONCENTRATIONS MAY BE ABOVE TLV
LIMITS. BELOW TLV, USE NIOSH APPROVED VAPOR RESPIRATOR.
Ventilation:LOCAL EXHAUST SUFFICIENT TO KEEP AIRBORNE VAPOR
CONCENTRATION BELOW TLV LIMIT.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:EYEBATH, SAFETY SHOWER. WEAR IMPERVIOUS
CLOTHING/BOOTS TO PREVENT CHRONIC CONTACT.
Supplemental Safety and Health
NK

HCC:F3
Boiling Pt:B.P. Text:240 TO 396F
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:<40 @ 20C
Vapor Density:>AIR
Spec Gravity:0.9927
pH:NA
VOC Grams/Liter:4.9
Viscosity:54-67 KU@77F
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PAINT, ALUMINUM COLOR
Percent Volatiles by Volume:76.8
Corrosion Rate:NA

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, WATER, MINERAL ACIDS, HARSH ALKALIES,
HALOGENATED COMPOUNDS
Stability Condition to Avoid:EXCESS HEAT, SPARKS, OPEN FLAME.
Hazardous Decomposition Products:THERMAL DECOMPOSITION OR COMBUSTION
MAY PRODUCE CARBON MONOXIDE, CARBON DIOXIDE, FORMALDEHYDE, AMMONIA,
NITROGEN OXIDES.

Waste Disposal Methods:IN ACCORDANCE W/FEDERAL, STATE, LOCAL LAWS.
INCINERATE ONLY IN EPA PERMITTED FACILITY. DON'T INCINERATE CLOSED
CONTAINER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.